The steering rack VAZ-2109 rarely needs replacing,much more often it is necessary to carry out its adjustment. You can perform all the actions in garage conditions. The reasons for which adjustment is necessary are most often covered in the knocking that occurs in the steering mechanism. On all front-wheel drive VAZ cars of the ninth and tenth generations the same rails are used.
Very often the knocking of the steering rack is confused with driverssimilar sound that comes from the side of the ball joints. But if, after diagnosing the hinge, you found out that it's in perfect order, you need to conduct a steering check. Usually, when driving on flat roads, no sound is heard. But as soon as there is a run on a hummock or hole, there is a knock. This may be due to the fact that the mounting of the VAZ-2109 steering rack has loosened.
All faults that appear in the steeringmechanism, are due to the fact that the car very often travels along uneven and dusty roads. If you are accustomed to driving on broken roads slowly, try to travel around larger irregularities, then by this you will save not only the steering rack VAZ-2109, but also all the most important elements of the suspension.
Very often the "young" drivers run into the curbs,which leads to a rapid deterioration of the steering components. But nothing compares to a torn anther. If water or dust gets into the mechanism, then the entire assembly will have to be replaced, since all rubbing parts will wear out very quickly. Symptoms of breakdowns:
Operate the car with a faulty steeringmanagement is impossible, so you need to start repair as early as possible. Only make sure that it is the rake that is faulty, not the ball stand or pillars. Otherwise, only in vain you will spend repair and will spend considerable money.
Before replacing the steering rack VAZ-2109, you must prepare. Please note that you will have to parse several nodes. Do the following:
That's all, now you can proceed with the removalmechanism. It is only desirable to clean all the elements from dirt, treat them with penetrating grease. Remove the wires that interfere with the access to the installation site of the VAZ-2109 steering rack.
The following actions are carried out according to this principle:
After all these actions, the rack can be removed through the wheel arch.
To restore the steering rack,buy a kit, which includes thrust needle bearings, plastic bushings, gaskets, rings, casing, racks, anther binders. On sale you can find only two types of repair kit: for partial and capital. It is preferable to use the first set, since there are more elements in it. Even if you only decided to replace the boot of the VAZ-2109 steering rack, then when you disassemble the unit, you will find many defects.
The following repair is carried out:
On this repair of the steering rack VAZ-2109 is over. Assembly of the whole assembly is done in the reverse order, new spare components are installed.
Please note that after a major repair or replacement of the steering rack VAZ-2109 will need to perform the following actions:
Be sure to look at the condition of the anthers. The quality of products that are sold in stores is different. Some can serve more than 10,000 km, others will not pass 1,000.
</ p>